Next Article in Journal
Development of Healthy, Nutritious Bakery Products by Incorporation of Quinoa
Previous Article in Journal
Relation between the Recipe of Yeast Dough Dishes and Their Glycaemic Indices and Loads
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Metschnikowia pulcherrima Selected Strain for Ethanol Reduction in Wine: Influence of Cell Immobilization and Aeration Condition

Dipartimento di Scienze della Vita e dell’Ambiente, Università Politecnica delle Marche, Via Brecce Bianche, 60131 Ancona, Italy
*
Author to whom correspondence should be addressed.
Submission received: 8 August 2019 / Revised: 27 August 2019 / Accepted: 30 August 2019 / Published: 1 September 2019
(This article belongs to the Special Issue Yeast in Food and Beverages Production)

Abstract

:
One of the most important problems in the winemaking field is the increase of ethanol content in wine. Wines with high ethanol level negatively affect wine flavor and human health. In this study, we evaluated the use of a selected strain of Metschnikowia pulcherrima in immobilized form and under different aeration conditions, to reduce the ethanol content evaluating the volatile profile of the resulting wines. In a preliminary screening the best conditions regarding free/immobilized cells, static/aerated fermentation and inoculation level were identified. Bench-Top fermentation trials with different aeration conditions showed that the use of M. pulcherrima selected strain with aeration flow of 20 mL/L/min during the first 72 h of fermentation, led an ethanol reduction of 1.38% (v/v) in comparison with Saccharomyces cerevisiae control strain. The analytical profile of the resulting wines did not show any negative feature. Indeed, the concentration of ethyl acetate, that above its sensory threshold impacts negatively the wine sensory profile, was found at an acceptable level. On the other hand, an increase in the concentration of significant fruity and flower compounds was found.

Graphical Abstract

1. Introduction

Today there is an increasing interest toward the reduction of ethanol content in wines. Indeed, the impact of climate change upon the global production of grapes and the current demand of well-structured and high phenolic content wines determine a generalized increase of ethanol concentration of wines [1,2,3]. Among the various methodologies proposed for the reduction of alcohol content in wine, the microbiological approach seems quite promising to avoid negative variations to the final wine composition [4]. In this regard, Saccharomyces cerevisiae, the main yeast species responsible for alcoholic fermentation during winemaking, is not the best yeast species for reducing alcohol levels in wine [5]. Indeed, in general, S. cerevisiae commercial starter strains showed similar high ethanol yields, so the researchers focused their attention on the development of new S. cerevisiae strains with modified fermentative pathway to obtain wines with reduced alcohol content [6,7,8,9]. On the other hand, non-Saccharomyces yeast species have shown great potential to produce less ethanol content in wine [10,11,12]. Indeed, non-Saccharomyces yeast can divert carbon away from ethanol production affecting ethanol yield, fermentation efficiency, biomass production and final by-products. In addition, respiro-fermentative regulatory mechanisms exhibited by some non-Saccharomyces yeasts (Crabtree negative) are different from that exhibited by S. cerevisiae (Crabtree positive). This metabolic behaviour can be exploited to reduce ethanol production through partial and controlled aeration of the grape juice [2,11,13,14]. A previous work [12] showed that the use of immobilized selected strains of Starmerella bombicola, Metschnikowia pulcherrima, Hanseniaspora osmophila and Hanseniaspora uvarum in sequential fermentation with S. cerevisiae, could be a suitable strategy to reduce the ethanol content in wine. Sequential fermentation allows to exploit the metabolism of non-Saccharomyces yeast while the immobilization procedure allows for high density of cells. In particular, immobilized cells of S. bombicola and M. pulcherrima under anaerobic conditions led an ethanol reduction of 1.6% and 1.4% respectively, exhibiting an increase of some key aroma compounds. Immobilized cells allow a large amount of cells in confined condition determining high reaction rate, specific physiological conditions and possible reuse. Recently, the use of non-Saccharomyces belonging to M. pulcherrima, Torulaspora delbrueckii and Zygosaccharomyces bailii species was investigated, at different aeration conditions to obtain wines with reduced ethanol content but with valuable volatile profile [15].
In the present work we evaluated the use of M. pulcherrima in sequential fermentations (M. pulcherrima/S. cerevisiae) at different aeration conditions to reduce the alcohol content and maintaining, at the same time, a good aromatic profile of wine. After a preliminary screening to optimize the modalities of inoculum and the effect of aeration, bench-top fermentation trials were carried out. The ethanol reduction and analytical composition of the final wines were evaluated.

2. Materials and Methods

2.1. Yeast Strains

M. pulcherrima DiSVA 269 used in this study was obtained from the Yeast Collection of Department of Life and Environmental Sciences (DiSVA) of Polytechnic University of Marche (Italy) and it was previously selected and evaluated in sequential fermentation trials in immobilized form and free cells under different aeration conditions [12,15]. This yeast was used in sequential fermentation trials with S. cerevisiae commercial strain Lalvin EC1118 (Lallemand Inc., Toulouse, France). S. cerevisiae strain was also used in pure culture as control. These strains were maintained on Yeast extract–Peptone–Dextrose (YPD) agar medium (Oxoid, Basingstoke, UK) at 25 °C for 48–72 h, and then stored at 4 °C.

2.2. Biomass Production and Immobilization Procedures

The biomass for free and immobilized trials was obtained using Modified YPD medium (0.5% yeast extract, 0.1% peptone, 2% dextrose, all w/v). M. pulcherrima cells were incubated at 25 °C for 72 h in a rotary shaker (150 rpm). The biomass for cell immobilization (5% wet w/v) was mixed with 2.5% Na-alginate (Carlo Erba, Milan, Italy) following the procedures described in Canonico et al. [12].

2.3. Screening Optimization Cell Concentration on Synthetic Grape Juice (SGJ)

A screening to optimize the immobilized cell concentration of M. pulcherrima was carried out in SGJ prepared following the procedures of Ciani and Ferraro [16] and Canonico et al. [12]. Briefly, SGJ was prepared using three different solutions: solution A (sugars); solution B, (tartaric acid, malic acid and citric acid); solution C (vitamins and survival factors). The three solutions were sterilized separately and then combined aseptically. The fermentation trials were set up in 100 mL flask that contained 70 mL SGJ under static and a rotary shaker (150 rpm) at 22 °C in triplicate. The inoculum for the immobilized cells of M. pulcherrima was 10%, 5%, 1% of beads (wet w/v) which corresponds to an inoculum of 1 × 108 cells/mL, 5 × 107 cells/mL and 1 × 107 cells/mL respectively. The same inoculum was carried out using free cells of M. pulcherrima. After 72 h of fermentation, free S. cerevisiae cells (1 × 106 cell/mL) were inoculated into the partially fermented grape juice without the removal of free or immobilized cells. At the end of fermentation, fermented products were subjected to chemical and microbiological analysis. The cell concentration trial that exhibited the best ethanol reduction was chosen to carry out fermentation in Natural Grape Juice (NGJ).

2.4. Fermentation Trials on Natural Grape Juice (NGJ)

For the fermentation trials in NGJ it was used sterile-filtered (membrane Ø = 0.45 µm) Verdicchio grape juice, an autochthonous white grape variety of Marche region (central Italy). Grape juice was obtained during 2015 vintage and maintained frozen until the use. The main characteristics of the grape juice were: pH 3.39; total acidity 4.42 g/L; total SO2, 34 mg/L; malic acid, 2.7 g/L; initial sugar content, 204 g/L; yeast assimilable nitrogen, 90 mg N/L.
Immobilized M. pulcherrima cells were evaluated in sequential fermentation trials on Verdicchio grape juice (initial inoculation level 5 × 107 cell/mL selected by the previous screening). After 72 h of fermentation, free S. cerevisiae cells (1 × 106 cell/mL) were inoculated into the partially fermented grape juice without removal of free or immobilized cells of M. pulcherrima.
The fermentations were carried out in 2 L bench-top bioreactor (Biostat® B; B. Braun Biotech Int., Goettingen, Germany) with 1.5 L of Verdicchio grape juice in gentle agitation (60 rpm/min) at 22 °C with the following aeration conditions during the initial 72 h: (i) no aeration; (ii) aeration flow of 1 mL/L/min; (iii) 20 mL/L/min. The inoculation level was 5 × 107 cell/mL of immobilized cells (corresponding to 5% wet w/v of beads). Control trials were carried out using free S. cerevisiae (106 cell/mL) under no aeration condition. The fermentation kinetics was determined by the evolution of sugar consumption using a specific enzymatic kit (Megazyme International Wicklow Ireland).
The cell release was analyzed by colony forming unit (CFU) counts on Lysine Agar (Oxoid, Hampshire, UK), a selective medium that does not support the growth of S. cerevisiae [17]. The fermentations were carried out in triplicate.

2.5. Analytical Procedures

The Official European Union Methods [18] were used to determine the ethanol content and volatile acidity g acetic acid/L). Acetaldehyde, ethyl acetate, n-propanol, isobutanol, amyl and isoamyl alcohols were quantified by direct injection into a gas-liquid chromatography system (GC-2014; Shimadzu, Kjoto, Japan). Each sample was prepared and analysed following the procedures of Canonico et al. [19]. Briefly, the main volatile compounds were determined by Solid-phase microextraction (HS-SPME) method. Five mL of each sample was placed in vial containing 1 g NaCl closed with a septum-type cap. HS-SPME was carried out under magnetic stirring for 10 min at 25 °C. After this period, an amount of 3-octanol as the internal standard (1.6 mg/L) was added and the solution was heated to 40 °C and extracted with a fiber Divinylbenzene/Carboxen/Polydimethylsiloxane (DVB/CAR/PDMS) fibre (Sigma-Aldrich, St. Louis, Missouri, USA ) for 30 min by insertion into the vial headspace. The compounds were desorbed by inserting the fibre into a Shimadzu gas chromatograph GC injector for 5 min. A glass capillary column was used: 0.25 μm Supelcowax 10 (length, 60 m; internal diameter, 0.32 mm). The fibre was inserted in split–splitless mode. The compounds were identified and quantified by comparisons with external calibration curves for each compound. The glucose and fructose (K-FRUGL), glycerol (K-GCROL), and succinic acid (K-SUCC) concentrations were determined using specific enzyme kits (Megazyme International, Wicklow Ireland).

2.6. Statistical Analysis

Analysis of variance (ANOVA) was applied to the experimental data for the analytical characters of wine. The means were analyzed using the STATISTICA 7 software (Stat Soft, Inc, Tulsa, OK, USA). The significant differences were determined using Duncan tests, and the data were considered significant if the associated p-values were <0.05.

3. Results

3.1. Screening to Assess Aeration, Different Modalities of Immobilization and Inoculation Levels of M. pulcherrima Sequential Fermentation in Synthetic Grape Juice (SGJ)

The preliminary screening was carried out under static and agitation conditions (150 rpm) in SGJ at 22 °C ± 1 °C and inoculated with M. pulcherrima (free and immobilized cells), at concentration 108 cell/mL (10% wet w/v of beads), 5 × 107 cell/mL (5% wet w/v of beads) and 107 cell/mL (1% wet w/v of beads). After 72 h of fermentation, S. cerevisiae EC 1118 was inoculated (106 cells/mL). The results of the main oenological parameter are shown in Table 1.
M. pulcherrima/S. cerevisiae sequential fermentation reduced the ethanol content in almost all conditions tested. M. pulcherrima in immobilized form improved the ethanol reduction in comparison with free cells in both static and agitated fermentation conditions. Agitation condition determined a further reduction in ethanol content. A significant ethanol reduction was obtained with 10% and 5% of M. pulcherrima immobilized cells both in static and agitation condition while 1 × 107 (1% immobilized cells) did not show significant reduction in comparison with free cells and S. cerevisiae control strain. Regarding the volatile acidity, only M. pulcherrima immobilized cells (10%) in agitation condition exhibited a significant increase in comparison with the other fermentation trials. Considering the results obtained in this preliminary screening, M. pulcherrima at inoculum level 5% corresponding to 5 × 107 cell/mL (the lowest active concentration) was selected for bench-top fermentation trials in NGJ using the following different fermentation conditions: semianaerobic condition (gently agitation 60 rpm), aeration flow of 1 mL/L/min and 20 mL/L/min.

3.2. Bench-Top Fermentation Trials

3.2.1. Sugar Consumption in Natural Grape Juice (NGJ) and the Main Analytical Characters

Figure 1 shows the sugar consumption of trials in different fermentation conditions.
At 72 h of fermentation, before the S. cerevisiae inoculum, M. pulcherrima with an aeration of 20 mL/L/min, exhibited a higher sugar consumption in comparison with the other sequential fermentation trials. On the other hand, at this time S. cerevisiae pure culture exhibited the faster sugar consumption in comparison with all the other trials. During the whole fermentation process, the sequential fermentation trials with 20 mL/L/min and 1 mL/L/min exhibited an intermediate consumption between S. cerevisiae pure culture and M. pulcherrima/S. cerevisiae in semianaerobic sequential fermentation that was the slowest fermentation. However, all sequential fermentations completely consumed the initial sugar content in grape juice and M. pulcherrima cell release from beads was lower than 103 cell/mL in all trials.
The main analytical characters of M. pulcherrima sequential fermentations under different aeration conditions at 72 h (before inoculum of S. cerevisiae) and at the end of fermentation are reported in Table 2.
Results of volatile acidity and glycerol content at 72 h did not show significant differences unlike ethanol content that showed significant differences among the trials. S. cerevisiae pure cultures displayed the highest production while the ethanol formation by M. pulcherrima was related to aeration indicating that the oxygen positively affects the fermentation rate of M. pulcherrima.
M. pulcherrima sequential fermentation with aeration flow of 1 mL/L/min and 20 mL/L/min increased significantly the glycerol content in the final wine in comparison with semianaerobic fermentation trials (M. pulcherrima/S. cerevisiae and S. cerevisiae pure culture). Similarly, to 72 h of fermentation, acetic acid content of final wines showed a comparable value among the trials.
The results of the final ethanol content highlighted a relevant differentiation among the fermentation trials. In the condition tested in semianaerobic condition M. pulcherrima/S. cerevisiae, there was an ethanol reduction of 0.51% (v/v) in comparison with S. cerevisiae control trial. This value was comparable with the ethanol reduction obtained with M. pulcherrima sequential fermentation with an aeration flow of 1mL/L/min. A significant increase of ethanol reduction of ca. 1.30% (v/v) was obtained with M. pulcherrima sequential fermentation with an aeration flow 20 mL/L/min. The data of ethanol yield reflected followed this trend.

3.2.2. The Main By-Products and Volatile Compounds of Sequential Fermentation with M. pulcherrima in Different Aeration Conditions in NGJ

To evaluate the influence of different aeration conditions on the aromatic profile of wines, the main volatile compounds produced in NGJ were assayed and the results were reported in Table 3.
A significant increase in ethyl acetate content in fermentation carried out with M. pulcherrima with aeration flow of 20 mL/L/min was found. However, differently from the results shown in similar conditions (sequential fermentation and aeration flow during the first 72 h) using free cells [15], the increase of ethyl acetate with immobilized cells was restrained and under the negative sensory threshold for this compound (175 mg/L) [20]. Moreover, this condition (immobilized cells and aeration flow of 20 mL/L/min) determined a significant increase of desirable volatile compounds such as ethyl butyrate and isoamyl acetate. In semianerobic condition, M. pulcherrima sequential fermentation exhibited a significantly higher amount of phenyl ethyl acetate in comparison with the other trials. Regarding the main higher alcohols M. pulcherrima sequential fermentation with aeration flow 1 mL/L/min exhibited a significant increase in amylic and isoamylic alchols, while with aeration flow 20 mL/L/min increased significantly the production of β-phenyl ethanol and isobutanol respectively. A significant increase of acetaldehyde content showed sequential fermentations under semianaerobic condition and 20 mL/L/min of air flow. However, acetaldehyde at these concentrations did not negatively influence the aromatic profile of the final wines. Regarding the carboxylic acids, a significant increase was found only for the diethyl succinate content in the trial with 20 mL/L/min of air flow, while no significant differences were exhibited in butyric acid content.

4. Discussion

One of the main issues related to winemaking is the progressive increase of the ethanol content in wine. The microbiological approaches seem an attractive strategy to reduce alcohol production [21]. Some of these strategies are focused on S. cerevisiae yeast genetically modified [6,7,8,22], evolution-based strategies, together with breeding strategies [9,23] while others focused the attention on the use of non-Saccharomyces wine yeast [13,21,24,25]. Here we evaluated the effect of different aeration condition and cell immobilization on M. pulcherrima sequential fermentation with S. cerevisiae on ethanol reduction and volatile profile of wines. In a previous study, the use of different non-Saccharomyces yeasts in immobilized form in anaerobic condition was investigated [12]. In particular, in that work the same strain of M. pulcherrima used in the present study, led an ethanol reduction of 1.4% (v/v) using 10% (w/w) of beads corresponding to an inoculation level of 108 cells /mL. In another recent work, using M. pulcherrima sequential fermentation (free cell inoculation) under aeration condition, a reduction of 1.6% (v/v) of ethanol content was obtained, however, this produced an excessive amount of ethyl acetate [15]. The addition of oxygen during the early stage of fermentation stimulates wine fermentation, favoring fermentation activity by promoting sterol and unsaturated fatty acids (UFAs) biosynthesis [26,27]. Results of this work confirm the helpful action of the oxygen on yeast metabolism improving the fermentation activity of M. pulcherrima immobilized cells highlighted by an increased sugar utilization kinetics.
In this work, the results of the ethanol content highlighted that the combined use of immobilized cells at reduced inoculation level (5% (wet w/v) of beads) and aeration flow 20 mL/L/min produced a relevant ethanol reduction (1.38% (v/v)) without the formation of ethyl acetate at an unacceptable level as free cells [15]. On the other hand, the amount of ethyl acetate formed is still relevant and could be controlled, optimizing the air flow during the first stage of fermentation.
Ethyl acetate is one of the main esters produced during wine fermentation, and while low concentrations impart a fruity aroma (below 80 mg/L), at concentrations above 160–170 mg/L give undesirable ‘nail polish remover’ and ‘solvent’ sensory descriptors [20]. On the other hand, some relevant aroma compounds such as ethyl butyrate and isoamyl acetate increased. This aspect is related to the oxygen supplementation as reported by Valero et al. [28] and Shekhawat et al. [29] that showed an increase in the concentration of esters and higher alcohols. Relative to the use of oxygen during wine fermentation, there are different results regarding its impact on different aromatic compounds. These controversial results could be due to the use of different strains, grape must and fermentation conditions [8,28,29,30].
Another important aspect is the reduction of the inoculum of immobilized cells. Indeed, in comparison to the previous work [12], it was halving the inoculum (5% (wet w/w) instead of 10% (wet w/w) of beads) that considerably reduced the use costs of this application, while maintaining a relevant reduction of ethanol content.
Regarding the acetic acid content, non-Saccharomyces yeasts generally produce an increase of acetic acid. This compound responsible for sour and bitter taste which is at higher levels of 0.9 g/L is considered detrimental for wine quality [11,14,20,29]. Rocker et al. [14] evaluated different non-Saccharomyces strains under anaerobic conditions and found the resulting wines with ‘vinegar’ sensory descriptor. In this study, M. pulcherrima tested in different fermentation conditions exhibited an acetic acid content comparable to the one exhibited by S. cerevisiae.
In summary, our results confirm the ability of non-Saccharomyces yeasts to produce wines with reduced ethanol content but it is necessary to set up the modalities of their use in function of the physiological and fermentation characteristics of the specie/strain. Here, we obtained a relevant reduction of ethanol and a valuable volatile composition of wines modulating oxygen supplied during the early stages of fermentation using the immobilized cells.

Author Contributions

L.C., F.C. and M.C. contributed equally to this manuscript. All authors participated in the design and discussion of the research. L.C. carried out the experimental part of the work. L.C., F.C. and M.C. carried out the analysis of the data and wrote the manuscript. All authors have read and approved the final manuscript.

Funding

This research was financially supported by OIV’s contribution. L.C. was supported by a grant of Università Politecnica delle Marche: D.R. n^ 1057 del 20.10.2016).

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Alston, J.M.; Fuller, K.B.; Lapsley, J.T.; Soleas, G. Too much of a good thing? Causes and consequences of increases in sugar content of California wine grapes. J. Wine Econ. 2011, 6, 135–159. [Google Scholar] [CrossRef]
  2. Gonzalez, R.; Quiros, M.; Morales, P. Yeast respiration of sugars by non-Saccharomyces yeast species: A promising and barely explored approach to lowering alcohol content of wines. Trends Food Sci. Technol. 2013, 29, 55–61. [Google Scholar] [CrossRef]
  3. Mozell, M.R.; Thach, L. The impact of climate change on the global wine industry: Challenges & solutions. Wine Econ. Policy 2014, 3, 81–89. [Google Scholar] [Green Version]
  4. Rolle, L.; Englezos, V.; Torchio, F.; Cravero, F.; Segade, S.R.; Rantsiou, K.; Giacosa, S.; Gambuti, A.; Gerbi, V.; Cocolin, L. Alcohol reduction in red wines by technological and microbiological approaches: A comparative study. Aust. J. Grape Wine Res. 2018, 24, 62–74. [Google Scholar] [CrossRef]
  5. Ciani, M.; Morales, P.; Comitini, F.; Tronchoni, J.; Canonico, L.; Curiel, J.A.; Oro, L.; Rodrigues, A.J.; Gonzalez, R. Non-conventional yeast species for lowering ethanol content of wines. Front. Microbiol. 2016, 7, 642. [Google Scholar] [CrossRef]
  6. Ehsani, M.; Fernandez, M.R.; Biosca, J.A.; Julien, A.; Dequin, S. Engineering of 2,3-butanediol dehydrogenase to reduce acetoin formation by glycerol-over producing, low-alcohol Saccharomyces cerevisiae. Appl. Environ. Microbiol. 2009, 75, 3196–3205. [Google Scholar] [CrossRef]
  7. Kutyna, D.R.; Varela, C.; Henschke, P.A.; Chambers, P.J.; Stanley, G.A. Microbiological approaches to lowering ethanol concentration in wine. Trends Food Sci. Technol. 2010, 21, 293–302. [Google Scholar] [CrossRef]
  8. Varela, C.; Torrea, D.; Schmidt, S.A.; Ancin-Azpilicueta, C.; Henschke, P.A. Effect of oxygen and lipid supplementation on the volatile composition of chemically defined medium and Chardonnay wine fermented with Saccharomyces cerevisiae. Food Chem. 2012, 135, 2863–2871. [Google Scholar] [CrossRef]
  9. Tilloy, V.; Ortiz-Julien, A.; Dequin, S. Biotechnology reduction of ethanol yield and improvement of glycerol formation by adaptive evolution of the wine yeast Saccharomyces cerevisiae under hyperosmotic conditions. Appl. Environ. Microbiol. 2014, 80, 2623–2632. [Google Scholar] [CrossRef]
  10. Varela, C.; Dry, P.R.; Kutyna, D.R.; Francis, I.L.; Henschke, P.A.; Curtin, C.D.; Chambers, P.J. Strategies for reducing alcohol concentration in wine. Aust. J. Grape Wine Res. 2015, 21, 670–679. [Google Scholar] [CrossRef]
  11. Contreras, A.; Hidalgo, C.; Schmidt, S.; Henschke, P.A.; Curtin, C.; Varela, C. The application of non-Saccharomyces yeast in fermentations with limited aeration as a strategy for the production of wine with reduced alcohol content. Int. J. Food Microbiol. 2015, 205, 15. [Google Scholar] [CrossRef] [PubMed]
  12. Canonico, L.; Comitini, F.; Oro, L.; Ciani, M. Sequential fermentation with selected immobilized non-Saccharomyces yeast for reduction of ethanol content in wine. Front. Microbiol. 2016, 7, 287. [Google Scholar] [CrossRef] [PubMed]
  13. Quiros, M.; Rojas, V.; Gonzalez, R.; Morales, P. Selection of non-Saccharomyces yeast strains for reducing alcohol levels in wine by sugar respiration. Int. J. Food Microbiol. 2014, 181, 85–91. [Google Scholar] [CrossRef] [PubMed]
  14. Rocker, J.; Strub, S.; Ebert, K.; Grossmann, M. Usage of different aerobic non-Saccharomyces yeasts and experimental conditions as a tool for reducing the potential ethanol content in wines. Eur. Food Res. Technol. 2016, 242, 2051–2070. [Google Scholar] [CrossRef]
  15. Canonico, L.; Solomon, M.; Comitini, F.; Ciani, M.; Varela, C. Volatile profile of reduced alcohol wines fermented with selected non-Saccharomyces yeasts under different aeration conditions. Food Microbiol. 2019, 84, 103247. [Google Scholar] [CrossRef] [PubMed]
  16. Ciani, M.; Ferraro, L. Enhanced glycerol content in wines made with immobilized Candida stellata cells. Appl. Environ. Microbiol. 1996, 62, 128–132. [Google Scholar] [PubMed]
  17. Lin, Y. Detection of wild yeasts in brewery. Efficiency of differential media. J. Inst. Brew. 1975, 81, 410–417. [Google Scholar] [CrossRef]
  18. Community Reference Methods for the Analysis of Spirits Drinks. Available online: https://www.eumonitor.eu/9353000/1/j9vvik7m1c3gyxp/vi8rm2yfaez6 (accessed on 8 February 2019).
  19. Canonico, L.; Comitini, F.; Ciani, M. Torulaspora delbrueckii for secondary fermentation in sparkling wine production. Food Microbial. 2018, 74, 100–106. [Google Scholar] [CrossRef]
  20. Ribéreau-Gayon, P.; Glories, Y.; Maujean, A.; Dubourdieu, D. Alcohols and other volatile compounds. In Handbook of Enology: The Chemistry of Wine Stabilization and Treatments; Ribéreau-Gayon, P., Glories, Y., Maujean, A., Dubourdieu, D., Eds.; John Wiley & Sons: Chichester, UK, 2006; pp. 51–64. [Google Scholar]
  21. Varela, J.; Varela, C. Microbiological strategies to produce beer and wine with reduced ethanol concentration. Curr. Opin. Biotechnol. 2018, 56, 88–96. [Google Scholar] [CrossRef]
  22. Rossouw, D.; Heyns, E.H.; Setati, M.E.; Bosch, S.; Bauer, F.F. Adjustment of trehalose metabolism in wine Saccharomyces cerevisiae strains to modify ethanol yields. Appl. Environ. Microbiol. 2013, 79, 5197–5207. [Google Scholar] [CrossRef]
  23. Abalos, D.; Vejarano, R.; Morata, A.; González, C.; Suárez-Lepe, J.A. The use of furfural as a metabolic inhibitor for reducing the alcohol content of model wines. Eur. Food Res. Technol. 2011, 232, 663–669. [Google Scholar] [CrossRef]
  24. Contreras, A.; Hidalgo, C.; Henschke, P.A.; Chambers, P.J.; Curtin, C.; Varela, C. Evaluation of non-Saccharomyces yeasts for the reduction of alcohol content in wine. Appl. Environ. Microbiol. 2014, 80, 1670–1678. [Google Scholar] [CrossRef] [PubMed]
  25. Gobbi, M.; De Vero, L.; Solieri, L.; Comitini, F.; Oro, L.; Giudici, P.; Ciani, M. Fermentative aptitude of non-Saccharomyces wine yeast for reduction in the ethanol content in wine. Eur. Food. Res. Technol. 2014, 239, 41–48. [Google Scholar] [CrossRef]
  26. Blateyron, L.; Sablayrolles, J. Stuck and slow fermentations in enology: statistical study of causes and effectiveness of combined additions of oxygen and diammonium phosphate. J. Biosci. Bioeng. 2001, 91, 184–189. [Google Scholar] [CrossRef]
  27. Fornairon-Bonnefond, C.; Aguera, E.; Deytieux, C.; Sablayrolles, J.M.; Salmon, J.M. Impact of oxygen addition during enological fermentation on sterol contents in yeast lees and their reactivity towards oxygen. J. Biosci. Bioeng. 2003, 95, 496–503. [Google Scholar] [CrossRef]
  28. Valero, E.; Moyano, L.; Millan, M.C.; Medina, M.; Ortega, J.M. Higher alcohols and esters production by Saccharomyces cerevisiae. Influence of the initial oxygenation of the grape must. Food Chem. 2002, 78, 57–61. [Google Scholar] [CrossRef]
  29. Shekhawat, K.; Porter, T.J.; Bauer, F.F.; Setati, M.E. Employing oxygen pulses to modulate Lachancea thermotolerans-Saccharomyces cerevisiae Chardonnay fermentations. Ann. Microbiol. 2018, 68, 93–102. [Google Scholar] [CrossRef]
  30. Fariña, L.; Medina, K.; Urruty, M.; Boido, E.; Dellacassa, E.; Carrau, F. Redox effect on volatile compound formation in wine during fermentation by Saccharomyces cerevisiae. Food Chem. 2012, 134, 933–939. [Google Scholar] [CrossRef]
Figure 1. Sugar consumption in sequential fermentation trials of M. pulcherrima/S. cerevisiae: semianaerobic ( Foods 08 00378 i001); aeration 1 mL/L ( Foods 08 00378 i002); aeration 20 mL/L ( Foods 08 00378 i003); and S. cerevisiae pure culture in semianaerobic ( Foods 08 00378 i004).
Figure 1. Sugar consumption in sequential fermentation trials of M. pulcherrima/S. cerevisiae: semianaerobic ( Foods 08 00378 i001); aeration 1 mL/L ( Foods 08 00378 i002); aeration 20 mL/L ( Foods 08 00378 i003); and S. cerevisiae pure culture in semianaerobic ( Foods 08 00378 i004).
Foods 08 00378 g001
Table 1. Main fermentation parameters of preliminary screening of M. pulcherrima in sequential fermentation trials with S. cerevisiae EC1118 inoculated after 72 h of fermentation in SGJ.
Table 1. Main fermentation parameters of preliminary screening of M. pulcherrima in sequential fermentation trials with S. cerevisiae EC1118 inoculated after 72 h of fermentation in SGJ.
Fermentation Trials.
(Agitation Condition)
Sugar Consumed
(g/L)
Ethanol
(%v/v)
Volatile Acidity
(g/L)
Fermentation Trials
(Static condition)
Sugar Consumed
(g/L)
Ethanol
(%v/v)
Volatile Acidity
(g/L)
S. cerevisiae219.8 ± 0.1 a12.49 ± 0.19 a0.45 ± 0.03 bcS. cerevisiae219.9 ± 1.6 a12.63 ± 0.12 ab0.42 ± 0.01 ab
M. pulcherrima free cells (10%)219.9 ± 0 a12.15 ± 0.21 ab0.40 ± 0.08 bcM. pulcherrima free cells (10%)219.9 ± 2 a12.42 ± 0.19 ab0.27 ± 0.01 b
M. pulcherrima free cells (5%)219.9 ± 0 a12.08 ± 0.08 ab0.45 ± 0.06 bcM. pulcherrima free cells (5%)219.9 ± 1.5 a12.57 ± 0.14 ab0.44 ± 0.05 ab
M. pulcherrima free cells (1%)219.9 ± 0 a12.31 ± 0.36 ab0.50 ± 0.00 bM. pulcherrima free cells (1%)219.7 ± 0.3 a12.72 ± 0.02 a0.39 ± 0.05 ab
M. pulcherrima immobilized cells (10%)219.9 ± 0 a11.87 ± 0.11 b0.60 ± 0.00 aM. pulcherrima immobilized cells (10%)219.9 ± 1.3 a11.92 ± 0.02 c0.43 ± 0.07 ab
M. pulcherrima immobilized cells (5%)219.9 ± 0 a11.95 ± 0.04 b0.36 ± 0.00 cM. pulcherrima immobilized cells (5%)219.9 ± 0.6 a12.38 ± 0.05 b0.39 ± 0.05 ab
M. pulcherrima immobilized cells (1%)219.8 ± 0.1 a12.07 ± 0.03 ab0.45 ± 0.00 abM. pulcherrima immobilized cells (1%)219.8 ± 0.5 a12.33 ± 0.04 ab0.50 ± 0.03 a
The initial sugar concentration was 220 g/L. Data are means ± standard deviations from three independent experiments. Data with different superscript letters (a,b,c) within each column are different homogeneous groups according to Duncan tests (0.05%).
Table 2. Main analytical characters of sequential fermentation with M. pulcherrima in different fermentation conditions semianaerobic, 1 mL/L/min and 20 mL/L/min at 72 h and at the end of fermentation.
Table 2. Main analytical characters of sequential fermentation with M. pulcherrima in different fermentation conditions semianaerobic, 1 mL/L/min and 20 mL/L/min at 72 h and at the end of fermentation.
72 h of FermentationGlycerol
(g/L)
Acetic Acid
(g/L)
Ethanol
(% v/v)
Ethanol Yield
(g/g)
End of FermentationGlycerol
(g/L)
Acetic Acid
(g/L)
Ethanol
(%v/v)
Ethanol Yield
(g/g)
M. pulcherrima
1 mL/L/min
0.41±0.01 b0.35 ± 0.00 a4.24 ± 0.15 c33.4 ± 0.13 bM. pulcherrima
1 mL/L/min
7.04 ± 0.14 a0.33 ± 0.03 b11.28 ± 0.14 b43.8 ± 0.16 c
M. pulcherrima
20 mL/L/min
0.41 ± 0.01 b0.34 ± 0.00 a6.20 ± 0.12 b37.7 ± 0.18 aM. pulcherrima
20 mL/L/min
7.12 ± 0.03 a0.36 ± 0.02 b10.62 ± 0.12 c41.2 ± 0.14 d
M. pulcherrima semianaerobic0.46 ± 0.04 b0.30 ± 0.00 b1.97 ± 0.18 d30.4 ± 0.14 cM. pulcherrima semianaerobic5.43 ± 0.09 b0.36 ± 0.02 b11.49 ± 0.08 b44.5 ± 0.04 b
S. cerevisiae semianaerobic0.47 ± 0.01 a0.33 ± 0.00 a8.65 ± 0.06 a38.6 ± 0.13 aS. cerevisiae semianaerobic5.15 ± 0.06 b0.38 ± 0.02 b12.00 ± 0.01 a46.5 ± 0.01 a
Data are means ± standard deviations from three independent experiments. Data with different superscript letters (a,b,c) within each column are different homogeneous groups according to Duncan tests (0.05%).
Table 3. Main volatile compounds of sequential fermentation with M. pulcherrima in different aeration conditions (mg/L).
Table 3. Main volatile compounds of sequential fermentation with M. pulcherrima in different aeration conditions (mg/L).
Fermentation TrialsM. pulcherrima
1 mL/L/min
M. pulcherrima
20 mL/L/min
M. pulcherrima SemianaerobicS. cerevisiae Semianaerobic
Esters
Ethyl butyrate0.12 ± 0.06 c0.96 ± 0.004 a0.575 ± 0.03 b0.14 ± 0.01 c
Isoamyl acetate0.25 ± 0.07 b1.67 ± 0.01 a0.240 ± 1.14 b0.136 ± 0.04 c
Ethyl hexanoate0.05 ± 0.02 b0.15 ± 0.09 a0.079 ± 0.05 b0.062 ± 0.02 b
Phenyl ethyl acetate0.021 ± 0.005 a0.01 ± 0.0006 a0.031 ± 0.020 a0.02 ± 0.002 a
Ethyl acetate46.3 ± 3.6 b169 ± 5.4 a37 ± 5.9 c23.00 ± 2.07 d
Alcohols
β-Phenyl ethanol18.52 ± 0.10 c30.42 ± 0.44 a26.20 ± 0.07 b9.655 ± 0.19 d
n-Propanol18.9 ± 0.4 b21.54 ± 1.74 a20.04 ± 1.89 a18.3 ± 2.0 b
Isobutanol58.9 ± 4.0 b120.50 ± 4.21 a42.13 ± 2.00 c14.9 ± 3.7 d
Amylic alcohol34 ± 5.64 a27.02 ± 1.17 b18.13 ± 3.45 c20.1 ± 0.4 c
Isoamylic alcohol241.6 ± 21.2 a181.81 ± 6.45 b164.3 ± 16.84 c159.61 ± 4.21 c
Carboxylic Acids
Butyric acid0.024 ± 0.003 a0.083 ± 0.06 a0.038 ± 0.006 a0.022 ± 0.002 a
Diethyl succinate0.002 ± 0.002 b0.024 ± 0.02 a0.008 ± 0.0 30 ab0.005 ± 0.000 b
Monoterpens
Linalool0.011 ± 0.003 a0.004 ± 0.01 b0.004 ± 0.002 b0.000 ± 0.001 c
Geraniol0.009 ± 0.003 b0.122 ± 0.003 ab0.006 ± 0.08 b0.232 ± 0.003 a
Carbonyl Compounds
Acetaldehyde14.91 ± 2.57 b50.52 ± 4.37 a66.9 ± 18.7 a22.50 ± 4.74 b
Data are means ± standard deviations from three independent experiments. Data with different superscript letters (a,b,c) within each row, are different homogeneous groups according to Duncan tests (0.05%).

Share and Cite

MDPI and ACS Style

Canonico, L.; Comitini, F.; Ciani, M. Metschnikowia pulcherrima Selected Strain for Ethanol Reduction in Wine: Influence of Cell Immobilization and Aeration Condition. Foods 2019, 8, 378. https://0-doi-org.brum.beds.ac.uk/10.3390/foods8090378

AMA Style

Canonico L, Comitini F, Ciani M. Metschnikowia pulcherrima Selected Strain for Ethanol Reduction in Wine: Influence of Cell Immobilization and Aeration Condition. Foods. 2019; 8(9):378. https://0-doi-org.brum.beds.ac.uk/10.3390/foods8090378

Chicago/Turabian Style

Canonico, Laura, Francesca Comitini, and Maurizio Ciani. 2019. "Metschnikowia pulcherrima Selected Strain for Ethanol Reduction in Wine: Influence of Cell Immobilization and Aeration Condition" Foods 8, no. 9: 378. https://0-doi-org.brum.beds.ac.uk/10.3390/foods8090378

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop