Next Article in Journal
Optimal Force Allocation and Position Control of Hybrid Pneumatic–Electric Linear Actuators
Next Article in Special Issue
Linearizing Control of a Distributed Actuation Magnetic Bearing for Thin-Walled Rotor Systems
Previous Article in Journal
Low-Cost, Open-Source Mechanical Ventilator with Pulmonary Monitoring for COVID-19 Patients
Previous Article in Special Issue
Analytical Analysis of Magnetic Levitation Systems with Harmonic Voltage Input
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

A Novel Low-Frequency Piezoelectric Motor Modulated by an Electromagnetic Field

School of Mechanical Engineering, Yanshan University, Qinhuangdao 066004, China
*
Author to whom correspondence should be addressed.
Submission received: 28 August 2020 / Revised: 10 September 2020 / Accepted: 11 September 2020 / Published: 13 September 2020
(This article belongs to the Special Issue Electromagnetic Levitation Actuators)

Abstract

:
For expanding the driving mode of the piezoelectric motor, a novel piezoelectric motor modulated by a magnetic field is proposed. This driving system combines piezoelectric driving and magnetic modulation together and can transform the reciprocating swing of the stator into step running of the rotor via the intermittent magnetic clamping between the rotor and stator. For investigating the inherent character of dynamics, the dynamic equations of key parts of the driving system are established. The natural frequencies and mode functions of the driving system are solved. A prototype was fabricated to prove the dynamic analysis and measure the output characteristic. The results show that the nature of the frequency measured from the test is coincident with theoretical analysis. In addition, by applying the driving frequency of 3 Hz, the voltage of the modulating signal of 4.5 V, the phase difference α between driving signal and modulating signal of 30°, the ideal outputs are 0.1046 rad/min for velocity and 0.405 Nmm for torque.

1. Introduction

With the continuous development of modern technology, the requirements for driving devices in intelligent manufacturing, optical fiber docking, biomedicine, and focusing systems are increasing. Piezoelectric motors are widely used in these fields because of their high displacement resolution, simple structure, and fast response [1,2]. For example, piezoelectric microrobots can be used in surgery, human digestive system monitoring and drug delivery [3,4]. Although many piezoelectric motors have been designed for various purposes, they can be roughly divided into three categories in terms of the driving principle: ultrasonic motors, inchworm piezoelectric motors and inertia piezoelectric motors [5].
The ultrasonic piezoelectric motor is the earliest and most widely used piezoelectric motor. According to the different driving signal waveforms, it can be divided into traveling wave ultrasonic motors and standing wave ultrasonic motors. Markus K. et al. [6], proposed a new type of traveling wave ultrasonic motor. The double input sliding mode controller, which uses frequency and phase difference as instructions, switches the control domain without interrupting the speed, reduces the control amount of phase difference, and does not produce overshoot. Chen W. et al. [7], proposed a radial bending ring traveling wave ultrasonic motor. The 40 slots on the outer surface of the stator ring are alternately filled with 20 piezoelectric stacks and 20 elastic blocks for generating traveling waves. The maximum speed of the motor can reach 146 r/min and the maximum torque is 1 Nm. Izuhara S. et al. [8], proposed a piezoelectric ultrasonic linear motor with hollow rectangular stator. The motor is a standing wave ultrasonic motor, which can directly drive its internal load through the stator. The structure saves the mechanism space, and has the advantages of fast response speed and high resolution.
The inchworm piezoelectric motor is a precision driving device that imitates the movement state of the inchworm and uses piezoelectric actuators. Mohammad T. et al. [9], proposed a two-axis inchworm piezoelectric motor, which consists of two integrated stages. Each stage provides continuous motion on one axis. It can be applied to an integrated precision positioning system with large stroke and multi-axis linkage. Xing J. et al. [10], proposed a new type of rotary inchworm piezoelectric motor. Due to the special structure of the stator, the driving mechanism can produce angular displacement during operation. The inchworm motor has the advantages of realizing adjustable clamping devices, and a simple structure of single parts. Dong H. et al. [11], proposed a linear inchworm piezoelectric motor, which consists of a driving mechanism and two clamping mechanisms. The overall structure of the motor is relatively simple, the power consumption is low, and the maximum operating speed is 0.72 mm/s.
An inertial piezoelectric motor is a motor that uses inertial impact force or torque to obtain linear or rotary motion. By varying the applied voltage, the actuators can take any position and therefore achieve the high motion resolution that is typical for piezo ceramics. Andrius C. et al. [12], designed a new type of inertial piezoelectric motor, consisting of a rectangular bronze stator, a clamping frame, a piezoelectric plate, and a conical rotor. The motor has a simple structure, good motion stability, and high space utilization. Wang L. et al. [13], proposed a new type of piezoelectric inertial rotary motor, which can be used to drive underwater micro-robots. The motor is composed of two rotors and a disc stator. It has a simple structure, small size, and good waterproof performance. The emergence of this motor has opened up a new way to develop advanced and flexible multifunctional robots. Mazeika D. et al. [14], designed a 3-degree-of-freedom high-resolution inertial piezoelectric motor. The motor can work in two vibration modes, namely the bending vibration mode of the outer shaft of the disc and the radial vibration mode of the disc. The bending vibration mode is used to rotate the rotor around the x and y-axis. The radial vibration mode is used to rotate the rotor around the z-axis. Therefore, 3 degrees of freedom movement of the motor is realized.
In summary, although piezoelectric motors have many advantages compared with traditional electromagnetic motors, the driving pattern of these piezoelectric motors is based on rigid contact between the fixed rotors to transmit power. The long-term effects of friction and preload force will cause damage to the runner or stator and even lead to the failure of the operation. Therefore, controlling the preload to reduce the friction between the contact surfaces is a key issue [15,16]. Introducing electromagnetic force into the piezoelectric motor improves not only the controllability of the clamping force or preload but also the friction and wear between the stator and rotor are effectively reduced. The proposed piezoelectric motor expands the topology structure of piezoelectric motors, and combining the piezoelectric drive and electromagnetic modulation into one motor would enrich the driving principle of the piezoelectric motor. In this paper, we mainly established the dynamics equations of key parts and solved natural frequencies and mode functions of driving system. We also conduct an experiment to measure the output characteristic of a prototype.

2. Motor Structure and Working Principle

2.1. Motor Structure Composition

The proposed piezoelectric motor is mainly composed of the driving part, the electromagnetic modulation part and the moving part. The driving part includes two piezoelectric stacks, a flexible amplifying mechanism and an intermediate shaft. The electromagnetic modulation part includes an electromagnet, a disc-shaped slider, and a spring. The rotor shaft and a bearing belong to the moving part of the motor, as shown in Figure 1.
In one part, two piezoelectric stacks cooperate with the flexible amplification mechanism for outputting swing motion, and then an intermediate shaft is assembled on the amplification mechanism as the driving part of the motor. In another part, the electromagnet matched with intermediate shaft, spring, and disc-shaped slider is combined as the electromagnetic modulation part of the motor. Finally, the drive part, the electromagnetic modulation part, and the moving part are assembled through the shell, end cover, pedestal, etc. to form a complete motor.

2.2. Working Principle

In the working step, the electromagnet attracts the disc-shaped slider and then rotates with the driving part. Considering that it takes a certain time for the disc-shaped slider to be attracted down after the electromagnet is energized, the piezoelectric stacks and the electromagnetic modulation mechanism are driven by two square wave signals with the same frequency but different phases separately. From Figure 2, Ua is the peak value of the driving voltage for the electromagnetic modulation part, while Ub is the peak value of the driving voltage for the piezoelectric stacks, T is one cycle of the motor operation, and Δt is the driving time difference of the two driving signals. This type of piezoelectric motor will present a stepping rotary motion, as shown in Figure 3.
The details of the working principle are as follows:
  • A square wave signal with peak value Ua of voltage is supplied to the electromagnetic modulation mechanism. So, the disc-shaped slider is attracted under the action of the electromagnetic force and keeps in contact with the upper surface of the electromagnet, as shown in Figure 3a.
  • After the time Δt, another square wave signal with peak value Ua of voltage, as shown in Figure 2, is applied to the piezoelectric stacks. Two piezoelectric stacks will produce elongation deformation, and then drive the electromagnetic modulation part and the rotor shaft rotation angle θ through the flexible amplification mechanism, as shown in Figure 3b.
  • When the high level of the driving signal Ua disappears, as shown in Figure 2, the disc-shaped slider would be separated from the electromagnet under the action of the spring force. After another period of time Δt, the driving signal Ub of the piezoelectric stacks is at low level. Then, two piezoelectric stacks restore to their original length and the electromagnetic modulation part returns to its original position with the elastic restoring force of the flexible amplifying mechanism, so the rotor rotates an angle θ relative to the electromagnet, as shown in Figure 3c. The time different Δt of each cycle of two driving signals prevents that the rotor shaft reverses due to inertia when the disc-shaped slider is separated from the electromagnet. Repeating the above steps can achieve continuous step rotation of the motor.

3. Analysis for Free Vibration

For solving the natural frequency and modal function, first, we need to establish the free vibration dynamic equation of the proposed piezoelectric motor. The key part of the piezoelectric motor mainly includes a driving part, an electromagnetic modulation part, and a moving part. For the establishment of the free vibration dynamics model, we consider the system condition of clamping the rotor with the electromagnetic force. Therefore, the electromagnetic modulation part and the moving part are simplified into one mass. Meanwhile, the flexible amplification mechanism also is simplified, as shown in Figure 4. According to the different vibration and structural characteristics of each component, free vibration equations of each subsystem need to be established respectively, and then the boundary condition and continuous condition can be utilized to solve the whole system free vibration characteristics. Since the structure of the flexible amplification mechanism is center symmetrical, here, only one side is used to carry out calculations.

3.1. Free Vibration Modeling of a Piezoelectric Stack

The piezoelectric stack elongates or recovers in the axial direction under signal excitation, so it can be simplified into a continuous system of axial vibration. The piezoelectric stack dynamics model is shown in Figure 5, in which δ (y, t) is the axial displacement equation of the piezoelectric stack, F is the axial internal force between the piezoelectric sheets, and f is the axial distribution force. Let the density of the piezoelectric material be ρp (y), the elastic modulus is Ep (y) = c33, and the cross-sectional area is Ap.
According to the dynamic model, the dynamic differential equation of the piezoelectric stack is established as follows:
ρ p A p 2 δ t 2 = c 33 A p 2 δ y 2
Let the solution of Equation (1) be:
δ ( y , t ) = ϕ ( y ) q ( t )
The modal function of piezoelectric stack can be obtained as:
ϕ ( y ) = W 1 sin ω y a + W 2 cos ω y a
where a = c 33 / ρ p , the coefficients W1, W2 and the natural frequency ω can be determined by the boundary conditions.

3.2. Free Vibration Modeling of Flexible Amplification Mechanism

Half of the flexible amplification mechanism is simplified into two beams (AB and BC) and a mass (CD). Two beams are considered as an elastomer and the mass is considered as rigid body. Each simplified unit is connected to others by flexible hinges. The dynamic model of half of the flexible amplification mechanism is shown in Figure 6. The flexible hinge is simplified into a combination of a rigid hinge and a coil spring. This part, the beam AB is taken as a research subject. We design the length of the beam AB to be greater than 5 times the height of the cross-sectional, so the driving beam AB is considered as an Euler–Bernoulli beam [10]. The origin of a coordinate system is set at point A. x-axis direction is along the length direction of the beam AB. When the beam AB is excited by piezoelectric stack, it presents bending vibration. Let the longitudinal displacement of the corresponding bending vibration of the beam be y1 (x1, t), the longitudinal distribution force on the beam be f1, the length of beam AB be l1, the density of the beam be ρq, the elastic modulus be E, the cross-sectional area be S1, and the longitudinal shear force be Fs.
According to the dynamic model, the dynamic differential equation of the beam AB is established as follows:
E I 4 y 1 ( x 1 , t ) x 1 4 + ρ q S 1 2 y 1 ( x 1 , t ) t 2 = 0
Let the solution of Equation (4) be:
y 1 ( x 1 , t ) = ϕ 1 ( x 1 ) q 1 ( t )
The modal function of the beam AB can be obtained as:
ϕ 1 ( x 1 ) = C 1 cos β x 1 + C 2 sin β x 1 + C 3 cosh β x 1 + C 4 sinh β x 1
where β = ρ q S 1 ω / E I 4 , the coefficients C1C4 and natural the frequency ω can be determined by the boundary conditions.
As the piezoelectric stack forces the beam AB to bending vibrate, the beam BC presents longitudinal vibration and slight lateral vibration. Here, the slight lateral vibration is negligible. We assume the length of the beam BC is l2, the cross-sectional area is S2, and the density constant of the beam is ρq.
Point B is set as origin of a relative coordinate system, and x2 axis is along the length direction of beam BC. As shown in Figure 7, F2 is the axial internal force acting on the beam cross section, f2 is the axial distribution force, lm is the length of the beam CD. Let the longitudinal vibration displacement of beam BC is u (x2, t).
According to the dynamic model, the dynamic differential equation of the beam BC is established as follows:
2 u 2 t 2 = E ρ q 2 u 2 x 2 2
Let the solution of Equation (7) be:
u 2 ( x 2 , t ) = ϕ 2 ( x 2 ) q 2 ( t )
The modal function of beam BC can be obtained as:
ϕ 2 ( x 2 ) = B 1 sin ω ρ q E x 2 + B 2 cos ω ρ q E x 2
The coefficients B1, B2 and the natural frequency ω can be determined by the boundary conditions.

3.3. Free Vibration Modeling of the Intermediate Shaft

The intermediate shaft is utilized to connect the electromagnetic modulation mechanism and the flexible amplification mechanism. The subsystem vibration model of the intermediate shaft and the electromagnetic modulation mechanism is shown in Figure 8, the simplified mass is arranged at an end of the shaft. Considering the intermediate shaft DE to be an ideal elastic body, when the motor is running, the intermediate shaft presents torsional vibration.
Assume that the material of the intermediate shaft is uniform, the density constant is ρz, the shear modulus is G, and the second moment of the cross section of the shaft is Iz. Point D is set as the origin of a relative coordinate system, z axis direction points to simplified mass md, θ is the angular displacement of the shaft torsional vibration, and fT is the torque per unit length in the axis direction.
According to the relationship between torque and angle, the partial differential equation of the torsional vibration of the intermediate shaft is:
2 θ t 2 = c 2 2 θ z 2
Let the solution of Equation (10) be:
θ ( z , t ) = ϕ 3 ( z ) q 3 ( t )
The modal function of the shaft DE can be obtained as:
ϕ 3 ( z ) = N 1 cos ( ω z c ) + N 2 sin ( ω z c )
where c = G / ρ z , the coefficients N1, N2 and the natural frequency ω can be determined by the boundary conditions.

3.4. Boundary and Continuity Conditions

After each subsystem vibration mode function of the motor is established, for solving the natural frequencies and the coefficients of the mode function, the boundary conditions and continues conditions need to be discussed and the mechanical relationship between subsystems determined.
From Figure 5, Figure 6, Figure 7 and Figure 8, the following relationship can be obtained at no load:
  • The end Op of piezoelectric stack is the fixed, so the displacement is zero at x = 0. It can be expressed as:
    ϕ ( 0 ) = 0
  • Regarding the beam AB, the displacement at point A of the driving beam AB is zero, and the bending moment is equal to the reverse moment of the coil spring, so:
    { ϕ 1 ( 0 ) = 0 E I ϕ 1 ( 0 ) = k ϕ 1 ( 0 )
    where k is the bending stiffness of the flexible hinge.
  • At the thrust point of the piezoelectric stack, the displacement equals to the elongation of the piezoelectric stack, and the thrust at y = lnp and the shear force at x1 = lFp are equal, so:
    { ϕ ( l n p ) = ϕ 1 ( l F p ) c 33 A p ϕ ( l n p ) = E I ϕ 1 ( l F p )
  • At endpoint B of beam AB, since the flexible hinge provides an elastic resilience, the shear force of point B equals the elastic force of the flexible hinge. It can be expressed as:
    E I ϕ 1 ( l 1 ) = k ϕ 1 ( l 1 )
  • Regarding the beam BC, when the flexible amplification mechanism is operating, beam BC exist a translational motion, and let the translational displacement be xp. Therefore, the displacement of the endpoint B of the beam AB is equal to the sum of the displacement of the endpoint C of the beam BC and the translational displacement xp. In addition, the shear force at x1=l1 and the thrust at x2 = 0 are equal, so:
    { ϕ 1 ( l 1 ) = ϕ 2 ( 0 ) + x p E I ϕ 1 ( l 1 ) = E S 2 ϕ 2 ( 0 )
  • At the endpoint C of beam BC, the superposition of the torque generated by the translation of the beam BC and the end moment of the bending beam AB are equal to the reverse moment of the flexible hinge, so:
    E S 2 ϕ 2 ( l 2 ) l m + E I ϕ 1 ( l 1 ) = k ϕ 2 ( l 2 )
  • For the junction of the intermediate shaft and mass m, the sum of the displacement at point C and the translational displacement xp is equal to the torsional angular displacement times the length lm. The torque at the endpoint E of the intermediate shaft is equal to the reverse torque of the mass md, so the boundary condition of the torsional intermediate shaft is:
    { ϕ 2 ( l 2 ) + x p = l m ϕ 3 ( 0 ) G I p ϕ 3 ( l 3 ) = J ω 3 2 ϕ 3 ( l 3 )
Then, substitute Equations (13)–(19) into the mode functions, respectively, to solve the natural frequency of each order of the system and the component mode coefficients.

4. Result Analysis

The flexible amplification mechanism was made of AA 7075 aluminum alloy. The intermediate shaft was made of AISI 1045 steel. The type of the piezoelectric stack was PSt150/5 × 5/20 (Core Tomorrow Technology Co., Ltd., Harbin, China). Table 1 shows the material properties and geometric parameters of piezoelectric stacks, flexible amplification mechanism and mass.
Under no-load state, substituting these parameters in Table 1 into Equations (13)–(19), the coefficients W1, W2, C1C4, B1, B2, N1, N2 and the natural frequencies of the piezoelectric stack, beams and intermediate shaft are obtained. The first three order natural frequencies are shown in Table 2.
According to the first three natural frequencies and coefficients W1, W2, C1C4, B1, B2, N1, N2, the modal function curves of the piezoelectric stack, beams of flexible amplification mechanism and intermediate shaft under no-load state are drawn by MATLAB, as shown in Figure 9, Figure 10 and Figure 11.
From Table 2 and Figure 9, Figure 10 and Figure 11, the following points can be summarized:
  • The natural frequencies of the 2nd and 3rd orders are greatly increased comparing with the 1st order. This is because when the 1st order free vibration is excited, the deflection of the piezoelectric stack, beam AB, and intermediate shaft DE basically present a linear change, and the deformation of the flexible amplification mechanism mainly occurs at the hinge, as shown in Figure 9. In addition, the modal stiffness of the flexure hinge is much smaller than the other beams, so the 1st order natural frequency is much lower than high order natural frequencies.
  • With the increase of the order, the modal functions of each component begin to present bending deformation. In the 2nd order modal functions curve, the beam AB appears a peak near 0.01 m and a trough near 0.027 m. In the 3rd order modal function curve, the piezoelectric stack appears a peak near 0.008 m, the beam AB appears a trough near 0.023 m and two peaks near 0.012 m and 0.036 m, and the shaft DE appears a trough near 0.01 m. However the beam BC has basically no obvious peaks and troughs.
  • Taking into account that the electromagnetic modulation mechanism is not suitable for working at high frequency, when the working frequency is selected to operate the motor, it should be less than the 1st order natural frequency.

5. Experiment and Discussion

To verify the analysis of free vibration of the piezoelectric motor, the test of the flexible amplification mechanism under excitation of the piezoelectric stacks was conducted. Then, the output characteristics of the prototype were measured for speed and torque.

5.1. Test for Free Vibration

In the free vibration experiment, a test system was built. The equipment included a computer, a HPV piezo drive power (Suzhou Boshi Robotics Technology Co., Ltd., Suzhou, China), the driving part of the motor, a OptoMET Digital LDV Vector Series laser vibrometer (OptoMET, Darmstadt, Hesse, Germany), and IOtech 625u data acquisition equipment (Beijing Perfect Technology Co., Ltd., Beijing, China). Figure 12 shows the flow chart of the free vibration test system. Figure 13 shows the experimental environment for measuring free vibration.
After establishing the test system, 5 test points with equal spacing were selected on the beam AB, as shown in Figure 14. Due to the limitation of experimental conditions, beam AB among the beams of the flexible amplification mechanism was easier to measure than other beams, and could fulfil the requirements of verifying free vibration theoretical calculations, so it was used as the test object. On the beam AB, the spacing of the five points was chosen by 8.5 mm. In addition, the theoretically calculated result of 1st order natural frequency was about 46.2 Hz, so the excitation frequency of 0~100 Hz was used for the frequency sweep test. In order to improve test accuracy and precision, each test frequency was recorded and averaged after multiple excitations.
For visual analysis of experimental and theoretical values, the frequency domain diagram of the 5th point on the beam AB was drawn and using the data of 5 test points, the mode shape was also fitted by the curve, as shown in Figure 15.
From Figure 15, the following conclusions can be obtained:
  • As shown in Figure 15a, for the 1st order natural frequency, the measured value is 38.5 Hz which is slightly lower than the theoretical value of 46.3 Hz. For the resonance displacement response amplitude of the beam AB end, the measured value is 1.35 mm which also is slightly lower than the theoretical value of 1.55 mm. The errors are 16.3% of the 1st order natural frequency and 12.9% of the response displacement.
  • As shown in Figure 15b, the displacement response of the 5 points marked on the beam AB conforms to the theoretically calculated 1st order free vibration. The resonance response displacement of 5th point is the largest, about 1.35 mm. The 1st point is located at the junction of the driving beam and the piezoelectric stack, and the resonance response displacement is the smallest, about 0.04 mm.
  • For the aforementioned errors, two reasons are summarized. The first reason is there was an error in the simplified model. The second reason is there also will be errors in measurement and data processing of the experiment. In addition, a wear-resistant gasket was added between the piezoelectric stack and beam AB, which will affect the experimental results by changing the contact stiffness.

5.2. Test of Output Characteristics

For the measuring output characteristics of the piezoelectric motor, another test system was established, which mainly included the computer, NI USB-6009 data acquisition card (Shenzhen Boruitu Electronic Technology Co., Ltd., Shenzhen, China), HPV piezo drive power (Suzhou Boshi Robotics Technology Co., Ltd., Suzhou, China), prototype, UNI-T direct current (DC) power supply (Unitech (China) Co., Ltd., Dongguan, China) and HP-5 micro force gauge (Yueqing Aidebao Instrument Co., Ltd., Yueqing, China ). Figure 16 shows the flow chart of the output characteristic test system. Figure 17 shows the experimental environment for measuring output characteristics.
In the test, the adjustment range of the drive voltage peak of the electromagnetic modulation mechanism was 3.5–5 V, the adjustment range of the drive signals frequency of the electromagnetic modulation mechanism and the piezoelectric stacks were 1–5 Hz, and adjustment range of the phase difference α between the electromagnetic modulation signal and the piezoelectric drive signal was 0–90°. In the speed measurement, the time of the prototype rotating a certain angle was recorded. Multiple measurements for speed were repeated to record the data, and the average speed of the prototype can be calculated. In the prototype torque measurement, a metal rod was mounted horizontally on the rotor shaft, and the thrust of the metal rod was measured with a micro force gauge. The micro force gauge could display the thrust of the metal rod test point, and the output torque could be calculated by the thrust. When the phase difference α was 50°, we investigated the operating status of the motor, as shown in Figure 18. The motor rotated about 9° in 120 s. This kind of motor presents a slow running state, from the measurement results.
To investigate the effect of driving signal parameters on speed and torque, more experiments were conducted. The change relationship curve of the speed and torque with different drive parameters was drawn, as shown in Figure 19.
From Figure 19, the following conclusions can be drawn:
  • When the frequency of the driving signal increases, the motor speed gradually increases and the torque gradually decreases. Since the electromagnetic modulation mechanism sensitivity is lower than piezoelectric stack, the driving signal frequency is not suitable as it is too high. In order to maintain the good output performance of the motor, here we take the driving signal frequency of 3 Hz. This not only ensures the normal speed of the motor, but also enables the motor to have a strong load capacity.
  • With the increase of the voltage of the electromagnetic driving signal, the motor speed decreases first and then tends to be stable. The overall torque shows a trend of slowly increasing. Since the electromagnetic voltage increases, the disc-shaped slider would be magnetized, which causes it to be unable to separate from electromagnet in time. Therefore, the electromagnetic driving voltage cannot easily exceed 4.5 V.
  • When increasing the phase difference α between the two drive signals, the motor speed increases first and then tends to be stable, and the change law of the torque is similar to the speed. In order to ensure the normal operation of the motor, the drive signal needs to keep a phase difference. In this way, it can avoid the electromagnet and the disc-shaped slider being unable to separate in time during operation. It explains why there is a time difference Δt between the two excitation signals in the driving principle.

6. Conclusions

A novel piezoelectric motor modulated by a magnetic field was proposed. The dynamic equations of the piezoelectric system were established for free vibration, the natural frequency and the vibration mode function were solved according to the continuity and boundary conditions, and the modal function curves were drawn and analyzed. In the free vibration test of the prototype, the relative error of the natural frequency between the test and the theoretical value was small, which verified the correctness of the free vibration theoretical analysis. In the output characteristics test, the prototype had a relatively stable output performance when the frequency of the motor drive signal was 3 Hz, the electromagnetic drive voltage was 4.5 V, and the phase difference between the electromagnetic modulation signal and the piezoelectric stack drive signal was 30°. This time, the motor output speed was 0.1046 rad/min, and the output torque was 0.405 Nmm. The novel electromagnetic modulation piezoelectric motor had some deficiencies. For example, due to the large coil volume, the motor was not easy to miniaturize, and the response of the electromagnetic modulation mechanism was slower. However, it had a higher resolution than the electromagnetically modulated piezoelectric motor with a speed of 2.28 rad/min (0.038 rad/s) proposed by Xing J. et al. [17]. The proposal of this novel piezoelectric motor provides a new idea for solving the friction problem of piezoelectric motors, and is of great significance for the further development and application of piezoelectric motors and dynamics research.

Author Contributions

Supervision, J.X.; project administration, J.X.; funding acquisition, J.X.; Conceptualization, J.X. and Y.Q.; methodology, J.X.; software, Y.Q.; validation, J.X. and Y.Q.; investigation, Y.Q.; resources, J.X.; data curation, Y.Q.; writing—original draft preparation, J.X. and Y.Q.; writing—review and editing, J.X. All authors have read and agreed to the published version of the manuscript.

Funding

This research was funded by National Natural Science Foundation of China, grant number 51605423 and Hebei Natural Science Foundation Project, grant number E2018203116.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Tian, X.; Liu, Y.; Deng, J.; Wang, L.; Chen, W. A review on piezoelectric ultrasonic motors for the past decade: Classification, operating principle, performance, and future work perspectives. Sens. Actuators A Phys. 2020, 306, 111971. [Google Scholar] [CrossRef]
  2. Tsai, X.-H.; Tao, Y.K.; Potsaid, B.M.; Jayaraman, V.; Kraus, M.; Heim, P.J.S.; Hornegger, J.; Mashimo, H.; Cable, A.E. Ultrahigh speed endoscopic optical coherence tomography using micro-motor imaging catheter and VCSEL technology. Biomed. Opt. Express 2013, 4, 1119–1132. [Google Scholar]
  3. Lee, W.-H.; Kang, C.-Y.; Paik, D.-S.; Ju, B.-K.; Yoon, S.-J. Butterfly-shaped ultra slim piezoelectric ultrasonic linear motor. Sens. Actuators A Phys. 2011, 168, 127–130. [Google Scholar] [CrossRef]
  4. Erturk, A.; Inman, D. Piezoelectric Energy Harvesting. Bull. Sci. Technol. Soc. 2011, 28, 496–509. [Google Scholar]
  5. Li, J.; Huang, H.; Morita, T. Stepping piezoelectric actuators with large working stroke for nano-positioning systems: A review. Sens. Actuators A Phys. 2019, 292, 39–51. [Google Scholar] [CrossRef]
  6. Kuhne, M.; Rochin, R.G.; Cos, R.S.; Rubio-Astorga, G.; Peer, A.; Santiesteban, R. Modeling and Two-Input Sliding Mode Control of Rotary Traveling Wave Ultrasonic Motors. IEEE Trans. Ind. Electron. 2018, 65, 7149–7159. [Google Scholar] [CrossRef] [Green Version]
  7. Chen, W.-S.; Liu, Y.; Yang, X.; Liu, J. Ring-type traveling wave ultrasonic motor using a radial bending mode [Correspondence]. IEEE Trans. Ultrason. Ferroelectr. Freq. Control. 2014, 61, 197–202. [Google Scholar] [CrossRef] [PubMed]
  8. Izuhara, S.; Mashimo, T. Linear piezoelectric motor using a hollow rectangular stator. Sens. Actuators A Phys. 2020, 309, 112002. [Google Scholar] [CrossRef]
  9. Tahmasebipour, M.; Sangchap, M. A novel high performance integrated two-axis inchworm piezoelectric motor. Smart Mater. Struct. 2019, 29, 015034. [Google Scholar] [CrossRef]
  10. Xing, J.; Zhang, N.; Li, C. Free vibration analysis of driving mechanisms of a rotary inchworm piezoelectric motor. China Mech. Eng. 2016, 27, 1996–2002. [Google Scholar]
  11. Dong, H.; Li, T.; Wang, Z.; Ning, Y. Design and experiment of a piezoelectric actuator based on inchworm working principle. Sens. Actuators A Phys. 2020, 306, 111950. [Google Scholar] [CrossRef]
  12. Andrius, C.; Dalius, M. An inertial piezoelectric plate type rotary motor. Sens. Actuators A Phys. 2017, 263, 131–139. [Google Scholar]
  13. Wang, L.; Hou, Y.; Zhao, K.; Shen, H.; Wang, Z.; Zhao, C.; Lu, X. A novel piezoelectric inertial rotary motor for actuating micro underwater vehicles. Sens. Actuators A Phys. 2019, 295, 428–438. [Google Scholar] [CrossRef]
  14. Mazeika, D.; Vasiljev, P.; Bareikis, R.; Borodinas, S. 3DOF High Resolution Inertial Piezoelectric Motor. In Proceedings of the 2019 IEEE International Ultrasonics Symposium (IUS), Glasgow, UK, 6–9 October 2019; Institute of Electrical and Electronics Engineers (IEEE): Glasgow, UK, 2019; pp. 1773–1776. [Google Scholar]
  15. Ueha, S.; Hashimoto, Y.; Koike, Y. Non-contact transportation using near-field acoustic levitation. Ultrasonics 2000, 38, 26–32. [Google Scholar] [CrossRef]
  16. Arabaci, T.; Çiçek, Y.; Dilsiz, A.; Erdogan, I.; Köse, Ö.; Kizildag, A. Influence of tip wear of piezoelectric ultrasonic scalers on root surface roughness at different working parameters. A profilometric and atomic force microscopy study. Int. J. Dent. Hyg. 2012, 11, 69–74. [Google Scholar] [PubMed]
  17. Xing, J.; Cao, C.; Qin, Y.; Ren, W. Tests of a Noncontact Piezoelectric Motor Modulated by an Electromagnetic Field. IEEE Trans. Ultrason. Ferroelectr. Freq. Control. 2020, 67, 124–130. [Google Scholar] [CrossRef] [PubMed]
Figure 1. Motor structure.
Figure 1. Motor structure.
Actuators 09 00085 g001
Figure 2. Drive signal.
Figure 2. Drive signal.
Actuators 09 00085 g002
Figure 3. Working principle. (a) Attracting state; (b) Clamping and rotating; (c) Restoring state.
Figure 3. Working principle. (a) Attracting state; (b) Clamping and rotating; (c) Restoring state.
Actuators 09 00085 g003
Figure 4. Simplified model of piezoelectric system for free vibration.
Figure 4. Simplified model of piezoelectric system for free vibration.
Actuators 09 00085 g004
Figure 5. Free vibration model of piezoelectric stack.
Figure 5. Free vibration model of piezoelectric stack.
Actuators 09 00085 g005
Figure 6. Free vibration model of driving beam.
Figure 6. Free vibration model of driving beam.
Actuators 09 00085 g006
Figure 7. Free vibration model of intermediate beam mass.
Figure 7. Free vibration model of intermediate beam mass.
Actuators 09 00085 g007
Figure 8. Free vibration model of intermediate shaft.
Figure 8. Free vibration model of intermediate shaft.
Actuators 09 00085 g008
Figure 9. The 1st order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Figure 9. The 1st order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Actuators 09 00085 g009aActuators 09 00085 g009b
Figure 10. The 2nd order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Figure 10. The 2nd order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Actuators 09 00085 g010
Figure 11. The 3rd order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Figure 11. The 3rd order modal function. (a) Piezoelectric stack; (b) beam AB; (c) beam BC; (d) intermediate shaft DE.
Actuators 09 00085 g011aActuators 09 00085 g011b
Figure 12. Flow chart of the free vibration test system.
Figure 12. Flow chart of the free vibration test system.
Actuators 09 00085 g012
Figure 13. The experimental environment for measuring the free vibration.
Figure 13. The experimental environment for measuring the free vibration.
Actuators 09 00085 g013
Figure 14. The beam AB free vibration test.
Figure 14. The beam AB free vibration test.
Actuators 09 00085 g014
Figure 15. The 1st order modal experimental results of beam AB. (a) Frequency domain diagram of the 5th point on the beam AB; (b) mode shape.
Figure 15. The 1st order modal experimental results of beam AB. (a) Frequency domain diagram of the 5th point on the beam AB; (b) mode shape.
Actuators 09 00085 g015
Figure 16. Flow chart of the output characteristic test system.
Figure 16. Flow chart of the output characteristic test system.
Actuators 09 00085 g016
Figure 17. The experimental environment for measuring output characteristics.
Figure 17. The experimental environment for measuring output characteristics.
Actuators 09 00085 g017
Figure 18. Experimental effect when the phase difference α is 50°. (a) At 0 s; (b) at 40 s; (c) at 80 s; (d) at 120 s.
Figure 18. Experimental effect when the phase difference α is 50°. (a) At 0 s; (b) at 40 s; (c) at 80 s; (d) at 120 s.
Actuators 09 00085 g018
Figure 19. The law of the speed and torque of the prototype with different drive parameters. (a) Change with the driving frequency; (b) change with the electromagnetic drive voltage; (c) change with the phase difference α of the two drive signals.
Figure 19. The law of the speed and torque of the prototype with different drive parameters. (a) Change with the driving frequency; (b) change with the electromagnetic drive voltage; (c) change with the phase difference α of the two drive signals.
Actuators 09 00085 g019aActuators 09 00085 g019b
Table 1. Free vibration calculation parameters.
Table 1. Free vibration calculation parameters.
ρp (g/cm3)ρq (g/cm3)Iq (cm4)md (kg)S1 (mm2)
7.52.8152.083.58 × 10−325
S2 (mm2)ρz (g/cm3)Lm (mm)G (Gpa)J (kg/m2)
207.8510.7780.72.11 × 10−3
d33 (C/N)c33 (Gpa)lnp (mm)Ap (mm2)b (mm)
635 × 10−1255.620255
lFp (mm)l1 (mm)l2 (mm)l3 (mm)E (Gpa)
640.6419.732072
Table 2. First three order natural frequency under no-load state.
Table 2. First three order natural frequency under no-load state.
OrderNatural Angular Frequency (rad/s)Natural Frequency (Hz)
129146
2227,20736,179
3503,64180,198

Share and Cite

MDPI and ACS Style

Xing, J.; Qin, Y. A Novel Low-Frequency Piezoelectric Motor Modulated by an Electromagnetic Field. Actuators 2020, 9, 85. https://0-doi-org.brum.beds.ac.uk/10.3390/act9030085

AMA Style

Xing J, Qin Y. A Novel Low-Frequency Piezoelectric Motor Modulated by an Electromagnetic Field. Actuators. 2020; 9(3):85. https://0-doi-org.brum.beds.ac.uk/10.3390/act9030085

Chicago/Turabian Style

Xing, Jichun, and Yong Qin. 2020. "A Novel Low-Frequency Piezoelectric Motor Modulated by an Electromagnetic Field" Actuators 9, no. 3: 85. https://0-doi-org.brum.beds.ac.uk/10.3390/act9030085

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop